Jip's Kesev

[Jip86]

so the story goes like this...
I bought this little number off the local council at auction as the car was dumped, for the ridiculously high price of $20. no, thats not a typo

its a 1981 auto SE in midway blue with an equally beautiful blue interior. propper granny spec, it even had a crochure hook under the back seat:hehe:
so after i got it home and pulled the column apart so i could start it, (as i had no key) i realized the battery was fingered. so $150 and about an hour later with a little fuel dribbled down the carbie she ran like a dream.
Then i got some tyres off a mate, spent $50 getting them fitted/balanced and replaced the gearbox extension housing oil seal because it leaked. when i fixed the rust in the back window and fitted the locks and ignition barrel off the AE71 Spirit that i bought off a mate for $100 i got her rego'd.

22752

once rego'd i put these on

22753

the spirit as of monday

22754

the spirit after 4 hours tonight

22755

some parts that have decided to show up, there's many more in the post

22756

[Vaughn]

I see trumpets........20v?

[Jip86]

didn't take long for someone to spot them.
short term 4ac out of spirit so i can get rid of the rusty pos and get mine mobile again. i'm doin the sussy now as well as the 4ac swap because ive got the house and more importantly the shed to myself for the next 4 weeks.

then 7age, smallport head, st quads, cams etc its about 90% finished. unfortunatly no one i know has a degree wheel so i can dial in the cams :cries: i might have to buy one

[Jip86]

i took the 4ac crossmember from the spirit into work to sandblast and paint. hmmm...

before repairs
22799
after repairs
22800

i split the box off the engine and the clutch is down to the rivets. its a good thing i've already got a replacement

[Jip86]

its now got
xt130 struts
hilux calipers
Peugeot rotors
6kg front springs
koni yellows
4.5kg rear with ajps adj spring seat
trd blues
cheap 15x8s with 195/50s
hyundai rad with thermo fans
http://www.ae86drivingclub.com.au/dcimages/7/1/1/276634.jpg

its a bit further along now, water pump and alt on. vac lines finished, heater and water lines nearly done. bigport loom modded with smallport injector plugs and 20v tps wired in. still gotta wire up map sensor, alt and air temp sensor.
coil and igniter en route and i havent looked at the fuel system yet.
http://www.ae86drivingclub.com.au/dcimages/7/1/1/276635.jpg

[Jip86]

http://www.ae86drivingclub.com.au/dcimages/7/1/1/538264.jpg
engine bay finished.
280 deg cams and open quads sounds glorious and its a cranky little thing with the cams set at 104/104.
http://www.youtube.com/watch?v=hSRUdwaQo4M
so now the excuses for such a shit time,
-i'd only just changed the cam timing from 110/110 to 104/104 and hadn't tuned it properly yet so it coughed and nearly stalled
-the gearbox crunches if you try and do a fast gear change (its had a hard life)
-the next run it didn't cough but spun one wheel with the open borgy anyway (i actually ran .1 slower!)




so then i decided it doesn't make enough power so i bought one of these
http://www.ae86drivingclub.com.au/dcimages/7/1/1/399374.jpg

but first i need to finish putting this together, f series from a mk 2 corona...
http://www.ae86drivingclub.com.au/dcimages/7/1/1/399376.jpg

with kaaz lsd, 4.56:1 gears and s13 calipers/discs.
http://www.ae86drivingclub.com.au/dcimages/7/1/1/399377.jpg

[86coupe]

Pretty cool that from the death of one 86, there are now two crazy blue ke70's.

[Low Style]

that is a nice looking E7

[Jip86]

Pretty cool that from the death of one 86, there are now two crazy blue ke70's.

its funny how things work out, blue ke up north with the motor from my old 86 and mine here with the motor that was suppose to go in my old 86.



anyone got a fwd water/thermostat setup shoot me a pm.

[Jip86]

so haven't updated in awhile,
flared front guards and fitted ajps front lip,
http://www.ae86drivingclub.com.au/dcimages/7/1/1/506789.jpg
bought a fully rad muffler to make it quieter,
http://www.ae86drivingclub.com.au/dcimages/7/1/1/506790.jpg
swapped out the t3 ps arms and ncrca's for ajps modded corona arms and ajps 40mm rca's,

i bought the front struts with a coilover fit fitted with koni yellow shocks. the seals on the shocks went so i bought a new set, for a rav 4 actually

finally pulled my finger out and finished the f series, i made a concentric ring for the rotors and modded the original ke70 hand brake cables with the ends from the s13 ones and made them shorter to suit (not in pic),
http://www.ae86drivingclub.com.au/dcimages/7/1/1/506791.jpg
found a nite parts bell for a good price so fitted that too,
http://www.ae86drivingclub.com.au/dcimages/7/1/1/506792.jpg
made a gbox mount and had a 1 piece tailshaft made. I used an inclinometer to get the angle of the gbox the same as the diff flange, that's why mine hangs lower than some others (still nearly 100mm of clearance).
http://www.ae86drivingclub.com.au/dcimages/7/1/1/506793.jpg
fitted a saas fixed back seat i got cheap.

sc12 not on yet, i wanted to start drifting it n/a and add the power as i need it.

I've got arp main and head studs to go in when i rebuild it for lower comp and i just bought a 175mm dampened crank pulley for it as well for more booooost when i need it.

[sundee]

prob best toyota colour right there.

[Jip86]

I hate that colour! blue is my favourite but not that particular shade.

it looks funny atm because the front guards, lip and beaver are all repainted but the rest of the car isn't,
http://www.ae86drivingclub.com.au/dcimages/7/1/1/506794.jpg

[sundee]

really? i rate it hay... i had a dato 1600 in factory Blue.. looks very similar.. loved it.. only other toyota e7 colour i rate is the beige.
looks great with all the chrome surrounds

[Jip86]

Long overdue update!

Made 99.3kwatw n/a
33908

did a couple bitumen khanacross events this year at the go kart track in proserpine.
Second time on track, i knocked 2 seconds off from the first timehttps://www.youtube.com/watch?v=J9Qme7oKYZ8

did 2 drift days, the second being matsuri. engine lost compression after lunch on day 1:worried: I knew it was on the way out I'd been tipping oil into it for ages. compression test revealed 140,135,160,180.

So i've skipped the supercharger and gone straight to turbo.
33909

What intercooler......
33910

ARP main and head studs, genuine toyota bearings and gaskets, kelway manifold,cut/shut smallport plenum, gt2860rs.

[Zane k]

Yess! This is gonna be good

[Jip86]

33933
this happened yesterday...motor incar!

[Jip86]

Suppose i should update.
35276
Just a run in tune. Full 12psi wastegate pressure from 3500 rpm. Will be good with the full monty! 460nm of stump pulling torque!


35278
I want to redo the wiring on the right and maybe paint the plenum and turbo housing a darker silver.

35277
Started mocking up an airbox, i'm going to put one on the other side to cover the rad overflow, washer and water meth tank that i just bought.


Just in case anyone wants to hear it. camera phone so the audios a bit shitty.
https://www.youtube.com/watch?v=BDGqfH6C8Fk&feature=youtu.be

[Jip86]

35781

so bit more boost. cleaned up the fuel map a little after this and ended up at 184.3kw (forgot to take another pic)

18psi. only picked up 30kw but made a heap more torque. its an absolute weapon on the road.

[dansomerville]

Very nice! Many ae/ke's down that way?

[Jip86]

nah sfa.

my mate has one 2 hours away with a smallport, bolt ons ect.

There is one with a 4agze with a razorback ecu thats been through 3 owners but none have got it to run properly as yet.

Couple stock ones driven by old men full of rust.


This town is dominated my v8s and xr6t's. the imports are either silvias or skylines for the most part.